山東山汽工程機械(集團)有限公司
熱線電話:400-879-1999 山汽官方微信
鄭重聲明 購機 售后
在線詢價
熱線電話:400-879-1999
您現在所在的位置: 首頁> 新聞資訊 > 行業新聞 >

混凝土攪拌車拌筒出現故障怎么解決?

所屬分類:行業新聞 發布時間:2021-01-27 來源:http://www.whjchh.com 瀏覽量:18

凝土攪拌車由汽車底盤、攪拌筒、傳動系統、供水裝置、全功率取力器、攪拌筒前后支架、減速機、液壓傳動系統、進出料系統、操縱機構等部分組成。其工作原理:通過取力裝置將汽車底盤的動力取出,并驅動液壓系統的變量泵,把機械能轉化為液壓能傳給定量馬達,馬達再驅動減速機,由減速機驅動攪拌裝置,對混凝土進行攪拌。混凝土攪拌車拌筒不能轉動的原因及解決辦法介紹如下:
Concrete mixer truck is composed of truck chassis, mixing drum, transmission system, water supply device, full power take-off, front and rear supports of mixing drum, reducer, hydraulic transmission system, feeding and discharging system, control mechanism, etc. Its working principle: take out the power of the car chassis through the power take-off device, drive the variable displacement pump of the hydraulic system, convert the mechanical energy into hydraulic energy and transfer it to the quantitative motor, the motor drives the reducer, and the reducer drives the mixing device to mix the concrete. The reasons why the mixing drum of concrete mixer cannot rotate and the solutions are as follows:
1、運輸過程中有混泥土卡住了,清理干凈就沒有問題了。
1. If the concrete gets stuck during transportation, there will be no problem after cleaning.
2、液壓系統或發動機故障的處理:
2. Troubleshooting of hydraulic system or engine:
1)打開混凝土攪拌車攪拌筒檢修孔蓋,旋松馬達上高壓軟管的管接頭,旋轉拌筒使拌筒檢修孔斜向下,將砼從混凝土攪拌車攪拌筒檢修孔排出。
1) Open the manhole cover of the mixing cylinder of the concrete mixer, loosen the pipe joint of the high-pressure hose on the motor, rotate the mixing cylinder to make the manhole of the mixing cylinder inclined downward, and discharge the concrete from the manhole of the mixing cylinder of the concrete mixer.
2)將故障車的高壓膠管從馬達上卸下,把救援用的高壓膠管接上,另一端接在救援車的油泵上,并將應急用的回油管一端接在故障車的馬達泄油口,回油管另一端接在救援車的油泵回油口,利用救援車來控制故障車拌筒的旋轉,將砼排出。
全自動上料攪拌車
2) Remove the high-pressure hose from the motor, connect the high-pressure hose for rescue, connect the other end to the oil pump of the rescue vehicle, connect one end of the emergency oil return pipe to the motor oil drain port of the fault vehicle, and connect the other end of the oil return pipe to the oil return port of the oil pump of the rescue vehicle. Use the rescue vehicle to control the rotation of the mixing cylinder of the fault vehicle and discharge the concrete.
3、馬達發生故障,處理則較簡單,可把救援車的馬達卸下裝在故障車上,再將各個油管接好,啟動救援車即可將拌筒內的砼排出。
3. In case of motor failure, the treatment is relatively simple. The motor of the rescue vehicle can be unloaded and installed on the failure vehicle, then the oil pipes can be connected well, and the concrete in the mixing drum can be discharged by starting the rescue vehicle.
混凝土攪拌車發生故障時應及時判斷發生故障的原因,采取有效的措施將拌筒內的砼排出后再解決故障。
When the concrete mixer truck fails, it is necessary to judge the cause of the failure in time and take effective measures to discharge the concrete in the mixing drum before solving the failure.                         
熱門產品 / HOT PRODUCT

 

首頁 產品 電話 置頂
99视频在线精品国自产拍亚瑟|bt天堂在线 男人影视|秋霞A级毛片在线看理论片|亚洲日韩欧美在线无卡